概述：1、安裝場地的選擇十分重要。大型混凝土攪拌機的安裝場地需要平整，地坑口要略高于地面，以防止水流入坑內(nèi)。1 The selection of insta
1、安裝場地的選擇十分重要。大型混凝土攪拌機的安裝場地需要平整，地坑口要略高于地面，以防止水流入坑內(nèi)。
1. The selection of installation site is very important. The installation site of large concrete mixer shall be leveled, and the pit mouth shall be slightly higher than the ground to prevent water from flowing into the pit.
2、用起重設備將大型混凝土攪拌機吊起，安裝四個支腿,連接角鋼、斜撐、爬梯，并裝上下軌道，使其對準放入地坑內(nèi)。安裝大型混凝土攪拌機時應注意使機架保持在一水平面上,軌道架不得歪扭和錯位。
2. Lift the large concrete mixer with lifting equipment, install four legs, connect angle steel, diagonal brace and ladder, install upper and lower rails, align them and put them into the pit. When installing large concrete mixer, pay attention to keep the frame on a horizontal plane, and the track frame shall not be distorted and misaligned.
3、大型混凝土攪拌機使用前先檢查：送電先按動開關，再合刀閘，檢查操作是否靈；。震動器、滾筒運轉、撥料棍運轉是否正常；鋼絲繩在卷筒上的纏繞情況。
3. Check the large concrete mixer before use: press the switch before power transmission, and then close the knife switch to check whether the operation is flexible;. Whether the operation of vibrator, drum and paddle is normal; Winding of steel wire rope on drum.
4、一次上料不得過多，按配比上料，注意水灰比。攪拌均勻，一次攪拌時間不得少于一分鐘，正常拌好的砼，應是很稠粥狀。
4. Do not feed too much at one time. Feed according to the proportion and pay attention to the water cement ratio. The mixing shall be uniform, and the mixing time at one time shall not be less than one minute. The normally mixed concrete shall be very thick porridge.
5、電器部份應愛護，電纜要保護好，防止損壞。
5. The electrical parts shall be taken care of, and the cables shall be well protected to prevent damage.
6、臨時停軌時，應每隔二十分鐘，開動大型混凝土攪拌機，防止砼凝固或將滾筒內(nèi)砼倒出，用水沖洗滾筒。
6. In case of temporary rail stop, start the large concrete mixer every 20 minutes to prevent concrete solidification or pour out the concrete in the drum, and wash the drum with water.
7、砼澆灌完停機后，應及時將滾筒和機外的砂漿用水沖洗清理干凈。
7. After concrete pouring and shutdown, the drum and mortar outside the machine shall be washed and cleaned with water in time.
點擊撥打服務熱線：4008791999
