鏟車攪拌斗固定式混凝土攪拌機，應安裝在臺座上，當長期使用時，應埋置地腳螺栓；如短期使用，可在機座下鋪設枕木并找平放穩。
The fixed concrete mixer of forklift mixer bucket shall be installed on the pedestal. When it is used for a long time, anchor bolts shall be embedded; For short-term use, sleepers can be paved under the base, leveled and placed stably.
鏟車攪拌斗對于移動式混凝土攪拌機，應安裝在平坦堅硬的地坪上用方木或撐架架牢，并保持水平面輪胎不受力。如果使用時間過三個月以上時，應將輪胎卸下妥善保管輪軸端部應做好清潔防銹工作。
Forklift mixer bucket for mobile concrete mixer, it shall be installed on a flat and hard floor, firmly supported with square timber or support, and keep the horizontal tire free from stress. If the service time is more than three months, remove the tire and keep it properly. The end of the axle shall be cleaned and rustproof.
鏟車攪拌斗混凝土攪拌機啟動后，應使攪拌筒達到正常轉速后進行上料，上料后要及時加水，添加新料先將攪拌機內原有的混凝土卸出后才能進行，不得中途停機或滿載荷時起動攪拌機，反轉出料者除外。
After the concrete mixer of forklift mixer bucket is started, the mixing drum shall reach the normal speed before feeding. After feeding, water shall be added in time. Adding new materials can be carried out only after the original concrete in the mixer is unloaded. It is not allowed to stop halfway or start the mixer at full load, except for reverse discharging.
混凝土鏟車攪拌斗運送混凝土的時間不能過長。運送混凝土途中，攪拌斗不得長時間停轉，以防混凝土產生離析現象，司機應時常觀察混凝土情況。
The mixing bucket of concrete forklift truck shall not transport concrete for too long. During the transportation of concrete, the mixing bucket shall not stop for a long time to prevent concrete segregation. The driver shall often observe the concrete.
鏟車攪拌斗車內裝有混凝土時，在現場停滯時間不得超過1小時，如超時應立即要求現場負責人給予及時處理。
When the forklift mixer truck is loaded with concrete, the standstill time on the site shall not exceed 1 hour. In case of overtime, the person in charge on the site shall be required to deal with it in time.
中首重工攪拌斗鏟車是適用于修路工程、絕大多數新農村建設的施工現場，山區環境惡劣很多地方作業受環境限制的地方，中首重工研制的安裝在鏟車上的攪拌斗，成功代替了攪拌機，是行走式的攪拌機，只要鏟車能去的地方攪拌斗都可以帶著攪拌斗。
The mixing bucket forklift developed by China first heavy industry is applicable to the construction site of road construction projects and the vast majority of new rural construction. The mountainous environment is bad and many places are limited by the environment. The mixing bucket installed on the forklift developed by China first heavy industry has successfully replaced the mixer. It is a walking mixer. As long as the forklift can go, the mixing bucket can carry the mixing bucket.
攪拌斗裝載機利用成熟的裝載機生產技術和強制式混凝土攪拌機生產技術，把強制式混凝土攪拌機經過改裝安裝在裝載機的鏟斗位置，利用裝載機的液壓傳動裝置驅動攪拌機工作，既可發揮裝載機方便的性能和自行上料、卸料的優勢，又可以利用強制式混凝土攪拌機的拌合功能，一臺機械即可實現上料、拌合、轉場、卸料的多重功能。
Using mature loader production technology and forced concrete mixer production technology, the forced concrete mixer is refitted and installed at the bucket position of the loader, and the hydraulic transmission device of the loader is used to drive the mixer, which can give full play to the convenient performance of the loader and the advantages of self loading and unloading, The mixing function of the forced concrete mixer can also be used, and one machine can realize the multiple functions of loading, mixing, transfer and unloading.
This article is compiled and released by automatic mixer truck. Do you know something about these contents? For more information, please click: http://www.fxsgujg.cn We will have more wonderful content for you to see.
點擊撥打服務熱線：4008791999
